冻融循环条件下外掺剂对沥青混合料水稳定性的影响

兰州理工大学学报 ›› 2022, Vol. 48 ›› Issue (1): 107-113.

冻融循环条件下外掺剂对沥青混合料水稳定性的影响

李萍^*1, 毛昱¹, 王盟¹, 丁樊¹, 瞿晓成²

1.兰州理工大学土木工程学院, 甘肃兰州 730050;
2.甘肃省兰州公路局, 甘肃兰州 730050

收稿日期:2019-04-04 出版日期:2022-02-28 发布日期:2022-03-09
通讯作者: 李萍(1972-),女,江苏清江人,教授,博导.Email:lzlgliping@126.com
基金资助:
国家自然科学基金(51868047,51668041),甘肃省重点科技攻关项目(20YF3GA017)

Effect of external admixture on water stability of asphalt mixture under freeze-thaw cycle conditions

LI Ping¹, MAO Yu¹, WANG Meng¹, DING Fan¹, ZHAI Xiao-cheng²

1. School of Civil Engineering, Lanzhou Univ. of Tech., Lanzhou 730050, China;
2. Lanzhou Road Bureau of Gansu Province, Lanzhou 730050, China

Received:2019-04-04 Online:2022-02-28 Published:2022-03-09

摘要/Abstract

摘要： 为评价外掺剂对沥青混合料水稳定性的影响状况,采用水泥、消石灰、橡胶粉和高分子聚合物对AC-13和AC-16沥青混合料进行掺配,然后在冻融循环条件下通过劈裂强度评价其水稳定性能.首先通过高温稳定性、低温抗裂性及水稳性试验方法,确定了水泥和消石灰的最佳改性含量;其次通过沥青三大指标测试方法、弹性恢复试验及小梁弯曲试验分别获取了高分子和橡胶粉聚合物的最佳掺量;最后对含有最佳掺量外掺剂的两级配类型沥青混合料进行冻融条件下的劈裂试验.结果表明:水泥、消石灰、橡胶粉和高分子聚合物的最佳改性含量依次为3%、2%、20%和0.3%;四种外掺剂均能有效提高沥青混合料的劈裂强度,其中含橡胶粉的劈裂强度提高幅度最大,沥青混合料自身级配组成对其劈裂强度影响较大,同条件下AC-13的劈裂强度高于AC-16;随冻融循环次数的增大,沥青混合料的劈裂强度比均呈现下降趋势,且橡胶沥青的下降速率相对缓慢,抗劈裂效果最好.

关键词: 沥青路面, 冻融循环, 外掺剂, 最佳掺量, 劈裂强度

Abstract: In order to evaluate the effect of the external admixture on the water stability of the asphalt mixture, the cement, hydrated lime, rubber powder and high molecular polymer were incorporated into the AC-13 and AC-16 asphalt mixture, then the water stability performance were evaluated by the splitting strength under freeze-thaw cycles. Firstly, the optimum modification content of cement and hydrated lime was determined by high temperature stability, low temperature crack resistance and water stability test method. Secondly, the optimal blending amount of high molecular and rubber powder polymer was obtained by three major indicators of asphalt test methods, elastic recovery test and beam bending test. Finally, the two types of asphalt mixture containing the best blend of external admixtures were subjected to a splitting test under freeze-thaw conditions. The results show that the optimum modified contents of cement, hydrated lime, rubber powder and high molecular polymer are 3%, 2%, 20% and 0.3%, respectively. The four external admixtures can effectively improve the splitting strength of the asphalt mixture, among which the splitting strength with rubber powder increases the most. The gradation composition of asphalt mixture has a great influence on the splitting strength. Under the same conditions, the splitting strength of AC-13 is better than that of AC-16. With the increase of the number of freeze-thaw cycles, the splitting strength ratio of asphalt mixture shows a downward trend, and the rate of decline of rubber asphalt is relatively slow, and the anti-cracking effect is the best.

Key words: asphalt pavement, freeze-thaw cycles, external admixture, optimum dosage, splitting strength

中图分类号:

TU53

李萍, 毛昱, 王盟, 丁樊, 瞿晓成. 冻融循环条件下外掺剂对沥青混合料水稳定性的影响[J]. 兰州理工大学学报, 2022, 48(1): 107-113.

LI Ping, MAO Yu, WANG Meng, DING Fan, ZHAI Xiao-cheng. Effect of external admixture on water stability of asphalt mixture under freeze-thaw cycle conditions[J]. Journal of Lanzhou University of Technology, 2022, 48(1): 107-113.

参考文献

[1] 罗志刚,周志刚,郑健龙,等.沥青路面水损害分析 [J].地下空间与工程学报,2006,2(3):504-509,516.
[2] 司伟,马骉,汪海年,等.沥青混合料在冻融循环作用下的弯拉特性 [J].吉林大学学报(工学版),2013,43(4):885-890.
[3] 司伟,马骉,汪海年,等.高原寒冷地区沥青混合料冻融循环作用下劈裂性能分析 [J].武汉理工大学学报(交通科学与工程版),2013,37(4):805-808.
[4] 李龙龙,李萍,纪上青,等.添加抗剥落剂沥青混合料的冻融劈裂试验 [J].公路,2018,63(5):242-246.
[5] LITTLE D N,JONES D R.Chemical and mechanical processes of moisture damage in hot-mix asphalt pavements [C].Moisture sensitivity of asphalt pavements:A national seminar,Transportation Research Board,Washing-ton,DC.2003.
[6] BHASIN A,MASAD E,LITTLE D,et al.Limits on adhesive bond energy for improved resistance of hot-mix asphalt to moisture damage [J].Transportation Research Record,2018,1970(1):2-13.
[7] HOWSON J,BHASIN A,MASAD E,et al.Development of a database for surface energy of aggregates and asphaltbinder [R].Federal Highway Administration/Texas Dept.of Transportation,Austin,TX.2009.
[8] AZARHOOSA A R,NEJAD F M,KAODAII A.Using the surface free energy method to evaluate the effects of polymeric aggregatetreatment on moisture damage in hot-mix asphalt [J].Journal of Materials inCivil Engineering,2016,28(10):4016098.
[9] MCCANN M,SEBAALY P.A quantitative evaluation of stripping potential in hot mix asphalt using ultrasonic energy for moisture accelerated conditioning [J].Transportation Research Record Journal of the Transportation Research Board,2001,1767:48-49.
[10] 郑健龙,张洪刚,钱国平,等.水温冻融循环条件下沥青混合料性能衰变的规律 [J].长沙理工大学学报(自然科学版),2010,7(1):7-11.
[11] 李兆生,谭忆秋.沥青混合料冻融损伤特性研究 [J].中国科技论文,2014,9(11):1279-1281.
[12] 王旭东,戴为民.水泥、消石灰在沥青混合料中的应用 [J].公路交通科技,2001,18(4):20-24.
[13] 李萍,张盼,念腾飞,等.消石灰和水泥改性沥青混合料的路用性能 [J].兰州理工大学学报,2018,44(2):135-138.
[14] 李廷刚,李金钟,李伟.橡胶沥青微观机理研究及其公路工程应用 [J].公路交通科技,2011,28(1):25-30.
[15] 傅珍,延西利,蔡婷,等.沥青组分与黏度的灰关联分析 [J].郑州大学学报(工学版),2014,35(3):102-105.
[16] 黄云涌,刘朝晖,李宇峙.沥青混合料水稳性试验方法[J].交通运输工程学报,2002,2(2):19-22.